Honda Fit manuals

Honda Fit: A/C System Evacuation (With A/C)

Special Tools Required

caution
  • Air conditioning refrigerant or lubricant vapor can irritate your eyes, nose, or throat.

  • Be careful when connecting service equipment.

  • Do not breathe refrigerant or vapor.

NOTE:

A more efficient way to measure moisture removal is with a special tool called a thermistor vacuum gauge, measuring vacuum levels in microns.

Connect the tool according to the manufacturers instructions, and allow the vacuum pump to run until the gauge reads 500 microns.

Shut off and isolate the vacuum pump, then observe the gauge reading:

  1. When an A/C system has been opened to the atmosphere, such as during installation or repair, it must be evacuated using an R-134a refrigerant recovery/recycling/charging station. If the system has been open for several days, the receiver/dryer should be replaced, refrigerant oil should be drained and replaced with new oil, and the system should be evacuated for several hours.

  1. Connect an R-134a refrigerant recovery/recycling/charging station (A) to the high-pressure service port (B) and the low-pressure service port (C), as shown, following the equipment manufacturer's instructions.

  2. ABC
  3. Evacuate the system. The vacuum pump should run for a minimum of 30 minutes to eliminate all moisture from the system. When the suction gauge reads -93.3 kPa   (-700 mmHg, -27.55 inHg) for at least 30 minutes, close all valves, and turn off the vacuum pump.

  4. If the suction gauge does not reach approximately -93.3 kPa   (-700 mmHg, -27.55 inHg) in 15 minutes, there is probably a large leak in the system. Partially charge the system, and check for leaks.

See also:

Turn Signals
The turn signals can be used when the ignition switch is in ON . ...

Using HFL
HFL Buttons ( HFL Talk) button: Press to go directly to give a command or to answer an incoming call. (HFL Back) button: Press to end a call or to cancel a command. Help Features • To h ...

Door Locks
Each door has a lock tab on the top of the door. Push in the tab to lock the door, and pull it out to unlock. On Canadian DX model To lock the passenger’s door when getting out of the vehicle, ...

© 2025 Copyright www.hfitinfo.com